Diaphragm for valve crankcase ventilation Porsche Cayenne 3.2L M02.2Y

Diaphragm valve for crankcase ventilation Porsche Cayenne 3.2L M02.2Y 95511076500 955.110.76500

pcv ccv pvc
we make the membrane separately!

Membrane engine valve cover 3.2L M02.2Y

Over time, the diaphragm valve crankcase ventilation dries and breaks.
Torn through the membrane into the engine gets unaccounted mass air flow sensor.
As a result, the engine can be difficult to start, unstable work (especially at idle) can be misfiring, the same engine can get dust, which enhances the wear and tear of parts and mechanisms.
If the whistle is heard in the area of finding oil separator, then the membrane is torn.

We produce and sell this membrane separately.

Replacement instructions:
Remove the valve cover.
Remove the valve crankcase ventilation (mounted inside the valve cover).
Remove the cover membrane, set in exchange membrane porvanoy new.
Assemble in reverse order.

During the first run, after replacing the membrane, the engine may not work steadily
(This is due to the fact that when the membrane was torn fuel cards to reconfigure the computer, in accordance with the lambda probes that detect increases in oxygen content).
After replacing the membrane restores valve and leak persists unaccounted air control unit needs some time to adjust fuel cards.
Must be allowed to run the engine for a while, switch off the ignition and start again, the engine must reach normal operation.

Membrane PCV Cayenne 3.2 L M02.2Y, 955.110.76500, 95511076500

With age, the diaphragm of the valve of ventilation of crankcase gases (PCV Porsche) goes down.
Through the damaged membrane PCV Cayenne unaccounted MAF air gets into the engine.
As a result, the unstable engine idling, bad starting, possible misfiring.
At the same time the engine enters the dust from the road, it enhances the wear of parts and mechanisms. If in the area to find PCV Porsche, heard the whistle, so the membrane is torn.
Company Porsche sells the valve of ventilation system Assembly, the cost of which is about $400
We produce and sell membrane kwkh Kaen separately.
Manual PCV Cayenne:
Remove the vent valve crankcase gases.
Remove the cover kwkh Kaen and install new to replace a torn membrane.
Assembly in reverse order.
When you first start, after replacing the membrane, the cayenne, the engine may not sustainable (it is connected with necessity of adaptation of fuel cards).
After repair PCV Cayenne strengthening the efficiency of the valve, and also eliminates the leak of unaccounted air. ECU need some time to adjust the fuel map. You need to give the engine briefly, then turn the ignition off and start again. The engine will be released for normal operation.