Diaphragm separator VAG 06H103495 – $19.90
Diaphragm valve for crankcase ventilation VAG 06H103495 (06H103495E, 06H103495A, 06H103495B, 06H103495E, 06H103495J)
pcv ccv pvc
we make the membrane separately!
Membrane engine 1.8 TSI / 2.0 TSI TFSI
Over time, the membrane crankcase ventilation valve and drying tears.
Through the torn membrane into the engine gets unaccounted mass air flow sensor.
As a result, the engine can be difficult to start, unstable work (especially at idle) can be misfiring, as the engine can get the dust, which enhances the wear of parts and mechanisms.
If the whistle is heard in the area of finding oil separator, then the membrane is torn.
The manufacturer sells only separator assembly.
We produce and sell this membrane separately.
Remove the cover membrane, set to replace a torn membrane new.
Assembly in reverse order.
During the first run, after replacing the diaphragm, the engine can not work steadily
(This is due to the fact that when the membrane was torn fuel cards to reconfigure the computer, in accordance with the lambda probe, which recorded high oxygen content).
After replacing the valve membrane restores, and eliminated unaccounted suction air control unit needs some time to adjust fuel cards.
It should be allowed to run the engine for a while, switch off the ignition and start again, the engine must reach normal operation.
Oil separator VAG 06H103495E (06H103495A, 06H103495B, 06H103495E, 06H103495J, 06H103495A, 06H103495B, 06H103495E, 06H103495J) was placed on the following vehicles:
Audi A3 Cabriolet 2008 – 2013
Audi A3 / S3 / Sportb. / Lim. / Qu 2008 – 2013
Audi A4 allroad quattro: 2010 – 2015
Audi A4 / Avant 2008 – 2012
Audi A4 / S4 / Avant / quattro 2008 – 2012
Audi A5 / S5 Cabriolet 2010 – 2011
Audi A5 / S5 Coupe / Sportback 2008 – 2011
Audi Q5 2009 – 2012
Audi TT Coupe / Roadster 2007 – 2015
Audi TT / TTS Coupe / Roadster 2007 – 2015
Seat Exeo / ST 2009 – 2014
Skoda Octavia 2004 – 2013
Skoda Superb 2008 – 2015
Skoda Yeti 2010 – 2015
VW Amarok 2010 – 2015
VW Beetle 2012 – 2015
VW CC 2012 – 2015
VW Eos 2009 – 2015
VW Golf Variant 2010 – 2014
VW Golf / R32 / GTI / Rabbit 2010 – 2013
VW Golf / Variant / 4Motion 2007 – 2014
VW Jetta 2005 – 2014
VW Jetta Variant 2008 – 2014
VW Passat 2009 – 2011
VW Passat CC 2009 – 2012
VW Passat / 4Motion / Santana 2009 – 2015
WARNING, before buying, make sure that your car is equipped with oil separator VAG 06H103495, these cars are equipped with different engines which may establish other oil separators.