BMW
X5 E70 – OEM 61617200510 Valeo 405.154
X6 E71 – OEM 61617200510 Valeo 405.154
Over time, the wiper on BMW X5, X6 cars goes down, the brush “sticky” at work, or stop moving completely.
The reason is that the wiper motor BMW 61617200510 wear plastic pinion teeth licks.
Riding with a defective wiper is very dangerous, especially in winter.
The manufacturer sells only trapeze wiper assembly with an electric motor worth more than $400.
We produce and sell the gear motor wiper BMW 61617200510 separately.
Replacement instructions:
Remove the trapeze wiper with an electric motor.
Remove the motor from the trapeze.
We note in what position is relative to the gear lever. (the assembly will have to ask about the same position accuracy up to 1 mm is not needed after assembly will be exhibiting at the zero position, it is written below).
Knock out of the gear lever. (Watch the video at the top of the page)
Pressed into a new gear.
Under the plastic gear to put something soft, such as a magazine, it will protect it from damage during pressing of.
Gear to heat a hairdryer.
Do not try to “press in” the stem of the lever “control punches,” it may damage the gears.
As for the pressing of a vice can be used.
Installation should at room temperature.
Adding lubricant. (lubricant should be a lot, it has to fill all available space).
Set trapezoid in place, connect the electrical connector.
Without installing the wiper blade, wiper switch on, it is necessary to set the zero position.
After stopping the wiper set the wiper blade.
Repair of the wiper motor is over.
=====
Gear wiper X5 and X6
The wiper mechanism is indispensable in any car. Whatever the machine is, in our climatic conditions without wipers is not enough.
Therefore, the main thing that the windshield wipers always worked properly and did not fail in bad weather. The main component of wipers that causes them to move is for BMW E70 wiper motor. The cars are fitted with, typically, two brushes for cleaning the windscreen and one for rear window.
The wiper can operate in several modes – fast, slow or intermittent. Inside design is a small motor – wiper motor BMW X5 E70, the device return the wiper arms and cleaning the gum.
The most reliable detail of this mechanism plastic gear wiper X5, which is inside the motor. It is most often broken, because of a temporary wear. Wears gear from the motor to the trapeze wiper E70, specifically its teeth.
Symptoms of failure: the brushes can hang on for some time, wave once, and do not rise or cease to work. When it heard the sound of the motor, so the motor and the wiper-line BMW X5 E70 serviceable.
Faced with this problem, motorists do not always know how to repair and what the possible causes of failure.
There are only two options – to buy a-line wiper blade X5 E70 with a motor as a whole, it offers the manufacturer or take advantage of our development, i.e. to buy new gear. In the first case, it is very expensive, about $700, and it is not advisable to throw the whole mechanism, when failure came just one detail. To change gear absolutely not difficult and can be done independently. In the future, periodically check the system state of the motor of the wipers, or the wipers may not work at the right time, it is dangerous and often leads to emergencies. Gear fits on BMW X6. Safe travels with no breakdowns.
